ALL OF OUR CHEMICALS ARE ENVIRONMENTAL AND HAZARDOUS FRIENDLY WITH A NFPA RATING OF 0.
MATERIAL SAFETY DATA SHEET
SECTION I, GENERAL INFORMATION
PRODUCT NAME: VIPER EQUIPMENT WASH
GENERIC NAME: Surfactant blend
NFPA
Fire 0
Health 0
Reactive 0
Special 0
0=Least to 4=Extreme
PREPARED BY: Tierra
Industries, Inc. 1-(432)-381-6540
EMERGENCY NUMBER:
1-(432)-381-6540 REVIEWED AND UPDATED: 1-3-10
SECTION II, HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
Hazardous Component (CAS Number) OSHA PEL ACGIHTLV
none
SECTION III, PHYSICAL/CHEMICAL CHARACTERISTICS
pH, (of a 1% solution in water) 6.7-7.6
BOILING POINT, ND
SPECIFIC GRAVITY (H2O=1), 1.020
VAPOR PRESSURE, ND
EVAPORATION RATE (BuAc=1), ND
SOLUBILITY IN WATER, Soluble
APPEARANCE AND ODOR, Clear to Yellow Liquid, Pleasant
POUR POINT, (+)220 F
SECTION IV, FIRE AND EXPLOSION HAZARD DATA
FLASH POINT: (TCC)
Not Applicable
FLAMMABLE LIMITS:
LEL: NA UEL: NA
EXTINGUISHING MEDIA: ____Alcohol _____ Carbon Dioxide _____Foam _____Dry Chemical _____Water Spray
Flammable Limits based on most volatile ingredients
SPECIAL FIRE FIGHTING PROCEDURES – None
UNUSUAL FIRE AND EXPLOSION HAZARDS – None
SECTION V, REACTIVITY INFORMATION
STABILITY
PRODUCT IS: Stable
INCOMPATIBILITY
MATERIALS TO AVOID, Not Applicable
HAZARDOUS DECOMPOSITION OR BY-PRODUCTS, None
HAZARDOUS POLYMERIZATION; Will not occur
SECTION VI, HEALTH HAZARD DATA
ROUTES OF ENTRY
INHALATION? Possible
Irritant. No known hazards.
SKIN/EYES? Possible
Irritant. No known hazards.
INGESTION? Possible
Irritant. No known hazards.
HEALTH HAZARDS
ACUTE – None
CHRONIC, None Known
CARCINOGENICITY
LISTED IN NTP? – No
IARC – No
MONOGRAPHS? – No
OSHA REGULATED? – No
SIGNS AND SYMPTOMS OF EXPOSURE, Irritation of eyes and skin might develop upon contact.
MEDICAL CONDITIONS GENERALLY
AGGRAVATED BY EXPOSURE, None Known
EMERGENCY AND FIRST AID PROCEDURES,
EYE CONTACT, Flush eyes with water for 15 minutes, get medical advice.
SKIN CONTACT, Wash skin with soap and water. Remove any contaminated clothing. Get medical attention if symptoms develop and persist.
INGESTION, If swallowed induce vomiting immediately by giving two glasses of water and sticking finger down throat. Never give anything by mouth to an unconscious person. Call a physician.
INHALATION, Remove to fresh air. If not breathing give artificial respiration. Give oxygen if breathing is labored. Get emergency medical help. Contact physician
immediately.
SECTION VII, PRECAUTIONS FOR SAFE HANDLING
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED, Small spills, pick up with absorbent media. Store as non-hazardous waste. Large spills, contain with
dikes, pick up with vacuum truck. Handle as non-hazardous waste.
WASTE DISPOSAL METHOD, EPA approved non-hazardous waste disposal site. Follow applicable local, state and federal regulations.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE, None
OTHER PRECAUTIONS, None
SECTION VIII, CONTROL MEASURES
RESPIRATORY PROTECTION, (If concentration reaches or exceeds TLV), NIOSH approved organic vapor mask required. None required.
VENTILATION; LOCAL EXHAUST, Not Applicable
SPECIAL, ND
MECHANICAL, Not Applicable
OTHER, ND
PROTECTIVE GLOVES, Chemical resistant gauntlet type gloves to avoid irritation. None required.
EYE PROTECTION, Chemical goggles or full face shield to avoid irritation. None required.
OTHER PROTECTIVE EQUIPMENT, Boots, aprons, drench showers, eye wash as needed for protection against spills and/or splashes to avoid possible irritation. None required.
WORK HYGIENIC PRACTICES, Avoid contact with skin, eyes and clothing. After handling this product, wash hands before eating, drinking or smoking. If contact occurs, remove
contaminated clothing. If needed, take first aid action shown in SECTION VI. Launder contaminated clothing before reuse.
SECTION IX, TRANPORTATION INFORMATION – None required.
SECTION X, OTHER DATA
EPA HAZARDS,
Acute – No
Chronic – No
Flammability – No
Reactive – No
Sudden Release of Pressure – No
SARA Title III
Threshold Planning Quantity, NONE
Reportable Quantity, NONE
Section 313, Toxic Materials
Chemical Name – None
CAS Number
Weight %
TOXIC SUBSTANCES CONTROL ACT (TCSA), 40 CFR 710
Sources of the raw materials used in this mixture assure that all chemical ingredients present are in compliance with Sect. 8(b) Chemical Substance Inventory, or are otherwise in compliance with TSCA.
TERMS USED IN MSDS
Explanation of abbreviations used on this MSDS form.
NA – Not applicable
ND– Data not available
CS – Cancer Suspect Agent
OX – Oxidizer
COR – Corrosive
CALC – Calculate
EST – Estimated
STEL – Short Time Exposure Limit
TLV- Time Weighted Average, 8 hours
HMIS, PPI – Hazardous Material Identification System, Personal Protection
lbs. – pounds
Office: 806-368-5534
Fax: 806-368-5675
12402 Slide Rd., Ste. 204
Lubbock, TX 79424